2009 CATERPILLAR 329DL Excavator
|Type the characters|
in the image above, and press send.
|New Very Good Good Fair Poor|
Cleaning Required Machine cleaned and the cab
Notes Machine cleaned as well as the cab
Car Body There are four foot long cracks underneath the car body where it welds to the roller frame on both sides.
Eng. Enclose Hood / Stack
Engine Doors Damage on the left rear (radiator) door.
Fenders Right front storage box door latch will not work.
Grab Irons Left front cab handrail bent. Right front handrail bent.
Hood The hood is damaged.
Main Frame Welds
Radiator Grill & Shroud
Sheet Metal Damage on right front fuel tank cover.
Steps / Ladder The right front step is bent. Three of the roller frame steps are home made.
Safety Decals In Place No Right side glass has been replaced - no labels.
Horn Does not work. Need to troubleshoot.
GAUGES, OPERATOR STATION, CONSOLE
Air Conditioner Does not work. Need to troubleshoot.
EMS Panel / Warnings
Meter Service meter has been replaced. Currently showing 216.3 hours.
Seat Belt replaced 9/29/2015
Seat Cushion / Arm Rest Top seat cushion torn.
Back Up Alarm
Current Parts Manual
Current Safety Manual
Fuel Level 5%
Air Cleaners Air filters are dirty.
Belts / Pulleys
Exhaust / Muffler
Fuel Injection System
Turbocharger / Blower
Compression in Radiator
Fluid Levels OK? Need to add coolant.
Oil Leaks Valve cover and rocker box leaking.
Water in Oil
Oil Pressure (H/L/N)Normal
Leaks No Radiator cap replaced
Radiator replaced radiator cap
ELECTRICAL, STARTING AND CHARGING SYSTEM
Ether Aid Start aid tube broken.
Batteries / Cables 4 new batteries installed
Swing Drive Oil Level OK
Boom Cylinder Left lift cylinder is leaking oil around rod seal.
Bucket Cylinder Clamps that retain the tube to the cylinder is missing.
Control Linkage Excessive wear / movement in the bucket linkage / pins.
Operating Condition Hydraulic oil temperature sensor "voltage below normal" code is active.
Pumps & Valves Hydraulic oil leaks around center section. Need to remove covers to check further.
Travel Motors The right side will not tram at times and is very slow. Need to troubleshoot.
Boom Length (Actual Length) 20 foot 2 inches
Boom Pins Slight wear on pins. Some side to side movement.
Pins & Bushings
Stick Length 10 feet and 6 inches
Pins & Bushings The stick to bucket movement has 3/4" movement / wear. See "bucket linkage" for pricing.
Stick Conditions Bent in on the bottom. There is excessive slack between the sides of the stick and the bucket - excessive side to side movement.
Stick Pins Slight wear on pins / bearings. some side to side movement.
Quick Coupler (Make/Model)N/A
Bucket Linkage Excessive wear and movement in pins, linkage and bearings. Some broken bolts in the pin retainers.
Bucket Mounts Cracks on top left of the bucket.
Bucket Sides The sides of bucket are separating from the bottom of the bucket. Plate over bucket sides.
Teeth / Adapters
Link Part Number After market track.
Track Frame - Left There are three bottom roller bolts broken.
Track Frame - Right
Average Life Remaining Track - 63%, Idlers - 62%, Rollers - 64%
Notes Three rollers on the left side are worn too bad to measure.
|Measure (L)||Measure (R)||% Worn (L)||% Worn (R)||Potential Hrs (L)||Potential Hrs (R)|
|Carrier Rollers Front||156 mm||135 mm||32||120|
|Carrier Rollers Rear||157 mm||158 mm||24||16|
|Idlers Front||23 mm||21 mm||52||24|
|Links||114 mm||114 mm||16||16|
|Pins & Bushings (External)||63 mm||63 mm||36||36|
|Pins & Bushings (Internal)||812 mm||812 mm|
|Track Roller 1||16 mm||18 mm||8|
|Track Roller 2||18 mm||18 mm||8||8|
|Track Roller 3||18 mm||18 mm||8||8|
|Track Roller 4||20 mm||20 mm||40||40|
|Track Roller 5||18 mm||18 mm||8||8|
|Track Roller 6||17 mm||18 mm||8|
|Track Roller 7||N/A||20 mm||40|
|Track Roller 8||N/A||18 mm||8|
|Track Roller 9||N/A||17 mm|
|Track Shoes (Width)||31 1/2"||31 1/2"|
Pins & Bushings Turned? No
Planetaries / Diff
COMMENTS, MISC. REPAIRS, GENERAL REMARKS
New radiator cap installed
Machine cleaned and the cab
4 new batteries installed
New seat belt installed 9/29/2015
|Construction Equipment||Trucks||Trailers||Cranes||Parts & Attachments||Other Searches||Dealer Searches|
Year | State
Year | State
Year | State
Year | State
Auctions and Events
Industry Related Items